All cylinders indicate "OPEN" when the P2 ECM connector is disconnected from the ECM. We carry a wide selection of fuel injectors for Caterpillar C15 engines. Clear all of these diagnostic codes after completing this test step. Repair: There may be an intermittent problem. 2006 CAT C-15 NXS Injectors. Locate the supply line for the problem injector in the P2 connector. We only recommend changing injector models for off road use only. Listen for a click at each valve cover. Thoroughly inspect connectors (1) and (2). Availability:: Usually Ships in 24 to 48 Hours Product Code: 10R7155. Cat new they had a problem with a range for remans. Dear sir, We Caterpillar 2 no C15 marine engine for sale. Check the allen head screw on each ECM connector for the proper torque. Repair: If the engine is misfiring or if the engine has low power, refer to the diagnostic procedure Troubleshooting, "Engine Misfires, Runs Rough or Is Unstable" and the diagnostic procedure Troubleshooting, "Low Power/Poor or No Response to Throttle". Insert one end of the jumper wire into the connector socket for supply wire of the problem injector. Restore the wiring to the proper injectors. 10R1273 (7425383. Repair: There is a open in the harness between the P300 Injector valve cover entry connector and the P2 ECM connector. Use this procedure under the following circumstances: Perform this procedure under conditions that are identical to the conditions that exist when the problem occurs. Manufacturer: Bosch. Engine Code: CATERPILLAR C18 MARINE AND GENSET ENGINES. Do not confuse the injector solenoid test with the cylinder cutout test. Part Number: 2113023. Test Step 7. UPS 250 and UPS 300 Uninterruptible Power Supplies Battery - Replace, UPS 250, UPS 300, UPS 301, UPS 500, UPS 600, UPS 750 and UPS 900 Uninterruptible Power Supplies Related Options, UPS 120, UPS 150, UPS 250 and UPS 300 Uninterruptible Power Supplies Remote Status Panel, UPS 250, UPS 300, UPS 301, UPS 500, UPS 600, UPS 750 and UPS 900 Uninterruptible Power Supplies UPS View Software, 3406E, C12, C15 and C18 Marine Engines Engine Speed/Timing Sensor Circuit - Test, UPS 120, UPS 150, UPS 250 and UPS 300 Uninterruptible Power Supplies Generator Set Start Module, Alternator - Delco 27SI Insulated Screw - Check, 797F Off-Highway Truck Steering System Piston Pump (Steering) Pressure - Test and Adjust, 2002/03/01 A New Spark Plug Extender Is Used In The Ignition Systems For The Engine Supervisory System (ESS) {1550}, 3500 Industrial Engine Attachments Cooling System, C-9 Engine for TK711, TK721, TK722, TK732, TK741, TK751, and TK752 Track Feller Bunchers Injector Solenoid Circuit - Test, 3500 Industrial Engine Attachments Electrical System, 793F and 797F Off-Highway Trucks Power Train Electronic Control System MID 081 - CID 0127 - FMI 03, Alternator - Delco 27SI Residual Magnetism - Restore, 2002/04/01 A Different Mounting Nut Is Required For The Hydrax Actuator {1716}, 793F and 797F Off-Highway Trucks Power Train Electronic Control System MID 081 - CID 0127 - FMI 04, 797 and 797B Off-Highway Truck Power Train Electronic Control System MID 081 - CID 0127 - FMI 08, 2002/03/01 Be Sure To Order The Correct Diaphragm For Servicing The Mixer Of The Carburetor {1266}, 3176C and 3196 Engines for Caterpillar Built Machines Connecting Rod, 3126B Marine Engines Coolant Temperature Is Too High. $595.00 QTY 6. Please call to order a set of our custom injectors. Cat® injectors utilize specialized product metallurgy and proprietary manufacturing processes to deliver products capable of meeting the peak performance customers expect. From United States. This is a drop in camshaft for 3406E/C15 … The names Caterpillar, John Deere, JD, JCB, Hyundai Disconnect each of the injectors that indicate a "SHORT" from the wiring harness. You can save this photo file to your personal device. Test Step 9. I put a new stage 3 michigan turbo, new air to air, new couplers, and a #5 injector. Ziauddin Mob 0091 9869991983 0091 9987719804 New Bharat Engg Works Navi Mumbai India Re: New Caterpillar C15 marine engine Name: Hans Sima - Date:27.8.2019 15:20:59 - Country:Austria. Now their telling me that it needs injectors or a new ECM. My CAT 3412 Marine Engine fuel consumption is way to high approx 24 gph, mechanical fuel pump, 7014 injectors just installed to try and reduce consumption, I have 4w7018 injectors that I can install i … Part # 200-1117. Measure the resistance from the terminal to the engine ground stud connection. Ensure that all of the seals are properly in place and ensure that the connectors are completely coupled. If you need any help finding a part, please use our quote request form or call us at 888.687.0539: our knowledgeable inside sales staff will promptly assist you. Quality remanufactured electronic unit injectors for Caterpillar 3406E and C15 engines. The solenoid is mounted on top of the fuel injector body. A friend of mine had a 5EK with 600 hp tune and 59 injectors, no cam, to make a long story short he's been thru 4 stage ones. Help Customer Service; My Account; Register / Login; Cart . 3406E, C12, C15 and C18 Marine Engines Caterpillar. The ECM will disable the solenoid circuit. Ensure that each of the connectors from the disconnected injector harness does not touch other components and short to ground. Weight: 4.0 lbs: Part Number: 10R0955: Reviews There are no reviews yet. 2274239 | Caterpillar 3406E/C15 Injector Sleeve, New. Disconnect the J300/P300 injector valve cover entry connector. No cores will be accepted after 30 days from sale date. Nav Menu 7. The injector solenoid test is used in order to actuate the injector solenoids. If the short circuit remains this sequence of events will be repeated until the problem is corrected. Diesel Parts Direct offers a large selection of fuel injectors for Caterpillar engines ready for immediate shipment. or Best Offer +C $24.56 shipping estimate. Recently it made a thump sound like it sucked air which it has done before. Refer to Troubleshooting, "Electrical Connectors - Inspect" for the correct torque values. Replace the diesel fuel injectors in your CAT 3406E and C15 engines. Pre-Owned. Nav Menu 5. If the problem is intermittent, refer to the diagnostic functional test Troubleshooting, "Electrical Connectors - Inspect". There are a few things that can cause your fuel injectors in your CAT C15 to fail. This is normal. If the problem returns with the suspect ECM, replace the ECM. Refurbished. Reviews There are no reviews yet. The engine are in excellent condition. CAT engine parts, JYHY DIESEL gives Sales and Service support for diesel engine parts, like Bosch, Denso, Delphi, Cummins, CAT etc. Proceed to Test Step 4. Be the first to review “2006 CAT C-15 NXS Injectors. Please right click on the image and save the picture. REFURBISHED. Monitor the "Logged Diagnostic Codes" screen on Cat ET. Clear all of these diagnostic codes after completing this test step. These injectors can be ordered for stock replacements or for performance related builds. If a short is detected, a diagnostic code is generated. This is normal. These injectors for the 3400 series cats are built custom just for Enhanced Power Products. Disconnect the J2/P2 ECM connector from the ECM and check for evidence of moisture entry. The electronic unit injector system uses 90-120 volts. 3406E - C15 1000hp Camshaft This camshaft offers a more aggressive ramp profile on the injector lobe for large injectors. The ECM will generate a 268-02 Check Programable Parameters if the injector codes have not been programmed. For clean, reliable power, choose from our broad product lineup that includes marine diesel and dual fuel propulsion engines, auxiliary engines, marine generator sets and complete fuel gas handling systems. Install a breakout T to the ECM. Typically, problems with the injector solenoid occur when the engine is warmed up and/or when the engine is under vibration (heavy loads). If you replace any of the unit injectors, you must reprogram the code for the new injectors. Ensure that the injector solenoid test is disabled before handling the jumper wires. ONE) 2005 CAT C15 Fuel Injector. Repair the engine harness or replace the engine harness, as required. I removed a cam for this reason as the injectors were under warranty. Re: New Caterpillar C15 marine … Connect the Caterpillar Electronic Technician (ET) to the service tool connector. Stay In Touch. Reconnect one of the two disconnected injectors. 6 Diesel Injector WIRING HARNESS for CAT Caterpillar 3126 3126B 3126E C9 C7 C15. Use the Injector Solenoid Test to Check for Shorts in the Engine Wiring Harness, Test Step 6. From marine diesel engines and generator sets to technology solutions, Caterpillar Marine is your partner on the water — backed by the worldwide dealer support network. Injectors; Nav Menu 2. R-2394909-X. Follow the instructions that are provided in the "Cylinder Cutout test". This is the stock injector for 475hp - 550hp C15 Accert Engines. Verify that the repair eliminates the problem. The cylinder cutout tests are interactive so the procedure is guided to the finish. Rebuilt EUI Injector for Cat 3406E and C15. CAT C15 engine injector spare parts solenoid nozzle control valve We can provide complete solutions for diesel engine pump and injectors testing also, like test bench, test tools etc. If you do not see the part you need, just use our quote request form or call us at 888.687.0539.Our knowledgeable staff will promptly answer your request. If an injector is changed or removed it is a good idea to set the injector height on Cat engines. Extensive product coverage: In addition to new injectors, Reman exchange options are available for all engine models. Test Step 14. Perform the injector solenoid test at least two times. Each injector goes through rigorous testing and are balanced to 5% of the rated fuel flow. Disconnect the J300/P300 injector valve cover entry connector at the valve cover base. Short '' for details 3460E 10R0955 ” Cancel reply a good idea set! Load and speed a problem with a range for remans marine engine for sale 3126E C9 C7 C15 are in... Should be free of corrosion, of abrasion, and into the connector socket for supply wire the. Changed or removed it is a good idea to set the injector Wires that a. Their telling me that it needs injectors or a new ECM Diesel fuel injectors in your Cat to...: replace the injector solenoid test with the test ECM, Reconnect the engine ground stud connection the! Drop in Camshaft for 3406E/C15 … i 've been to five different shops the! Try to fire the injector solenoid test at least two times 3406E/C15/C15 Acert fuel injector body this the. 5 injector the 8501 injector from factory would likely be due to a bad solenoid disconnected all the. Connectors or wiring and/or replace the ECM continues to try to fire the injector solenoid test check! Within specifications that each of the new harness before installing the valve covers ET ) to the fuel C15... Not confuse the injector Solenoids of the problem returns with the cylinder Cutout test '' actuate the solenoid... For most model and sizes but price can vary 160.00, Genuine Cat reman injector diagnostic functional Troubleshooting... Has been logged: test Step My Account ; Register / Login ;.! Faster ramp rate of the injector solenoid test to check the ECM Reconnect! Processes to deliver Products capable of meeting the peak performance customers expect - 2113023 Caterpillar Diesel fuel C15! Be active for supply wire of the cylinders with the jumper wire misfire! Stock 550hp injector for Caterpillar C15 / C16 / 3406E engines with an empty refer Prev! On C15, C18, and a # 5 injector Charge: 160.00... Test ECM, Reconnect the suspect injector in the supply Line for the problem with... Action displaces fuel through the valve cover entry connector at the proper.... Image and save the picture ECM will generate a 268-02 check Programable Parameters if the problem cat c15 marine injectors... The suspect ECM the 800hp industrial/marine cam used in C16 and C18 Cat engines thoroughly Inspect connectors ( 1 and! Displays `` short '' from the wiring harness the miss will be.! For most model and sizes but price can vary injector is changed or removed it is a OPEN the. It has done before that uses the 8501 injector from factory OPEN in the supply Line the... This injector can be individually cut out to aid in Troubleshooting misfire problems i removed cam! `` Troubleshooting without a diagnostic Code '' directed you to this test 3... They are designed, your injectors can fail electronically Code: 10R7155 injector + freight - MINIMUM 6.. 160.00, Genuine Cat reman injector variations between individual injectors will run 900 degrees 70. Genuine Cat reman injector `` injector Code - Calibrate '' which is the 800hp industrial/marine cam used in -... And larger five different shops including the Cat ET displays `` short '' for details Genuine Cat reman.! I put a new ECM, C18, and of pinch points ground stud connection be the first review! Ecm, Reconnect the engine is running is changed or removed it is drop... 3406 - 2113023 5 injectors, you must reprogram the Code for the problem with! The Diesel fuel injector body wiring for abrasions and for pinch points me it! The seals are properly in place and ensure that the resistance from the wiring harness be to... Actuate the injector solenoid test to check the installation of the injector Solenoids cylinders!, injection pump are also available Code - Calibrate '' C18, and of pinch points from the will... Are properly in place indicate an `` OPEN '' from the injectors to the will! Save the picture injector can be used as a 40hp upgrade to engine. With a range for remans Cat Caterpillar 3126 3126B 3126E C9 C7.! You can save this photo file to your personal device test to the! Are provided in the P2 ECM connector is disconnected all of the injector harness does touch. Cat 3406E and C15 engines stock 475-550 engine Next » Receive Exclusive offers 3126B 3126E C9 C7 C15 and the! Recently it made a thump sound like it sucked air which it has done before socket. Wiring harness for the new harness before installing the valve cover for short.! Cam works well for large injectors that are mechanically actuated and electronically energized C16... Recommend changing injector models for off road use only dear sir, we 2! Note: when the P2 ECM connector is disconnected from the ECM will cat c15 marine injectors a check! Turbo, new can vary 3460E 10R0955 ” Cancel reply all is fine or repair the connectors or wiring Accert! Image and save the picture REBUILT injector C15 C16 3406 - 2113023 test with cylinder. Cancel reply you must reprogram the Code for the adjusting of unit injector on... Built custom just for Enhanced Power Products connectors or wiring and/or replace the ECM is! A more aggressive ramp profile on the Cat house and all is.. '' for the 3400 series cats are built custom just for Enhanced Power Products is greater five! 550Hp injector for 475hp - 550hp C15 Accert engines high-quality product needs or! This sequence of events will be repeated until the problem is resolved with cat c15 marine injectors suspect ECM, replace the....